FAA mandates seaplane inspections after Puget Sound crash

Nov 2, 2022, 7:35 PM | Updated: 7:45 pm

SEATTLE (AP) — Federal regulators on Wednesday ordered seaplanes like one that went down in Washington’s Puget Sound in September be inspected for a flaw that likely caused the deadly crash.

The Federal Aviation Administration airworthiness directive requires that operators of all the DHC-3 Otter seaplanes in the United States — 63 of about 160 operating worldwide — examine the stabilizer to confirm the condition of an actuator piece, The Seattle Times reported. That piece was missing from the Friday Harbor Seaplanes aircraft that crashed Sept. 4 into the waters near Whidbey Island, killing 10 people, newspaper reported.

Operators must confirm that the stabilizer actuator lock ring is correctly installed and report back to the FAA by Dec. 19, according to the directive. The order does not ground the aircraft.

Kenmore Air, the largest Otter operator on Puget Sound, has said its aircraft have passed inspection.

On Oct. 24, the National Transportation Safety Board, which is investigating the crash, urged operators to ground all those particular planes until the part is inspected, noting it would be up to the FAA to issue a grounding order. Last week, the NTSB officially called for the FAA to require inspection of the planes.

“We’re concerned that another plane could crash as a result of something similar,” NTSB Chair Jennifer Homendy said at the time.

In an investigative update, the NTSB identified a lock missing from the actuator of the horizontal tail — also known as a stabilizer — which controls the pitch of the plane.

After crews recovered about 85% of the plane wreckage in September, investigators found the upper portion of the actuator was attached to the horizontal stabilizer, while the lower part was “attached to its mount in the fuselage” but disconnected.

While the NTSB has not officially said the actuator separation caused the crash, Homendy said the failure of the actuator could have caused the plane to plummet. Additional crashes could happen if the lock pin is missing or improperly installed.

An FAA spokesperson told The Seattle Times on Wednesday that the directive was issued after the manufacturer, Viking Air Limited, issued a service bulletin.

A problem with pitch control would be consistent with the “nose dive” reported by people who saw the plane hit Puget Sound.

Witnesses helped officials identify the crash site, search for survivors and locate the remains of one passenger.

It took the NTSB and U.S. Navy crews more than a week and several types of sonar to find what remained of the plane because of the depth and current of the channel where the aircraft hit. Remains of seven of the 10 people aboard have been located.

Copyright © The Associated Press. All rights reserved. This material may not be published, broadcast, rewritten or redistributed.


Police clear the area following a shooting at the Kansas City Chiefs NFL football Super Bowl celebr...

Associated Press

1 dead, many wounded after shooting at Kansas City Chiefs’ Super Bowl victory parade

One person died after 22 people were hit by gunfire in a shooting at the end of the Kansas Chiefs' Super Bowl victory celebration Wednesday.

7 days ago

This image from House Television shows House Speaker Mike Johnson of La., banging the gavel after h...

Associated Press

GOP-led House impeaches Homeland Security Secretary Mayorkas — by one vote — over border management

Having failed to impeach Homeland Security Secretary Alejandro Mayorkas the first time, House Republicans are determined to try again Tuesday.

8 days ago

Defense Secretary Lloyd Austin, right, and Kenya's Defense Minister Aden Duale, left, listen during...

Associated Press

Defense Secretary Lloyd Austin hospitalized with bladder issue

Defense Secretary Lloyd Austin has been hospitalized following symptoms pointing to an “emergent bladder issue."

10 days ago

Joel Osteen, the pastor of Lakewood Church, stands with his wife, Victoria Osteen, as he conducts a...

Associated Press

Woman firing rifle killed by 2 off-duty officers at Houston’s Lakewood Church run by Joel Osteen

A woman entered the Texas megachurch of Joel Osteen and started shooting with a rifle Sunday and was killed by two off-duty officers.

10 days ago

(Pexels photo)...

Associated Press

Baby in Kansas City, Missouri, dies after her mother mistakenly put her in an oven

An infant in Missouri died when her mother mistakenly put her down for a nap in an oven, a prosecutor said Saturday.

11 days ago

Former Arizona Department of Corrections boss Charles Ryan received probation on Feb. 9, 2024. (AP ...

Associated Press

Former Arizona corrections boss sentenced to probation over armed 2022 standoff with police

Former Arizona Corrections Director Charles Ryan was sentenced Friday to probation for his no-contest plea to a disorderly conduct charge stemming from a 2022 armed standoff at his Tempe home.

12 days ago

Sponsored Articles


Fiesta Bowl Foundation

The 51st annual Vrbo Fiesta Bowl Parade is excitingly upon us

The 51st annual Vrbo Fiesta Bowl Parade presented by Lerner & Rowe is upon us! The attraction honors Arizona and the history of the game.


Collins Comfort Masters

Avoid a potential emergency and get your home’s heating and furnace safety checked

With the weather getting colder throughout the Valley, the best time to make sure your heating is all up to date is now. 

(KTAR News Graphic)...

Boys & Girls Clubs

KTAR launches online holiday auction benefitting Boys & Girls Clubs of the Valley

KTAR is teaming up with The Boys & Girls Clubs of the Valley for a holiday auction benefitting thousands of Valley kids.

FAA mandates seaplane inspections after Puget Sound crash